How to Troubleshoot Your Fuel Gauge - - Jeep at Off-Road.com
Jeep »
How to Troubleshoot Your Fuel Gauge

Source: Jeep at Off-Road.com

To check the fuel guage (from the Haynes FSJ manual):

Set the ignition switch to ON.

If the gauge pointer does not move from empty, check the fuse. If the fuse is OK, locate the sender unit. Connect the sending unit connector to ground. If the pointer goes to the full position replace the sending unit. If the pointer stays in same position, use a jumper wire to ground the terminal on the back of gauge. If the pointer moves, the problem lies in the wire between the gauge and the sending unit. If the pointer does not move with the back of the gauge grounded, check for voltage at the other terminal of the gauge. If voltage is present, replace the gauge.

Checking the sending unit.

  1. Raise the vehicle and support it securely on jackstands
  2. If the fuel gauge on the instrument panel is malfunctioning, check the operation of the fuel level sending unit. If the fuel level sending unit operates in accordance with the following test, the problem may exist in the gauge or its circuit.
  3. Before performing any tests on the fuel level sending unit, make sure the sending unit has a good ground electrical connection.
  4. Raise the vehicle and support it securely on jackstands. [what, again?!?]
  5. Locate the fuel level sending unit electrical connector. On most models, the connector is located near the back of teh fuel tank near the fuel filler hose and the fuel vapor hose. However, some late models are equipped with an access hole under the rear seat or trunk area. Lift the rear seat, remove the retaining screws and remove the access cover plate.
  6. Position the probes of an ohmmeter into the electrical connector and check the resistance. Use the 200-ohm or low scale on the ohmmeter.
  7. With the fuel tank completely full, the resistance should be approximately 110 ohms. With the tank half full, the resistance should be approximately 55 ohms. With the fuel tank empty, the resistance sof the sending unit should be approximately 1 ohm.
  8. Note: a more accurate check of the sending unit can be made by removing it (fuel level sending unit of assembly) from the fuel tank and checking its resistance while manually operating the float arm.
  9. If the readings are incorrect, replace the sending unit.

    Bill Kelsey
    Aberdeen, SD
    '79 widetrack Cherokee "S"

Follow us on Twitter at www.twitter.com/OffRoadDotCom
Comments and questions from our Readers
 Posted May 27 2008 09:57PM
how do you check the ohms on an 85 cj7 fuel gauge? i know the gauge is broken but i want to check how much fuel is in the tank until the new gauge arrives. what is the range? someone told me 33ohms full and 240ohms empty and that didnt sound right to me. thanks!
 Posted Jul 14 2008 01:15PM
Just replaced the sending unit on 81 cj-5 now, the gauge reads full the tank only has 1/2 amount
 Posted Sep 29 2008 05:29PM
I have installed a new plastic gas tank in a 1980 CJ-7. After hooking up the proper ground and wiring, the fuel gauge always pegs out to full and does not move. Any help?? thank you, Chip
Read More Comments
post a comment
Your email address will NOT be published.
appears with your comment
read our privacy policy
Note: does not support HTML
All comments submitted are subject to review, and may be delayed before posting. We reserve the right not to post comments.
Untitled Document
Sponsored Links
Off-Road Videos -
Check out over ten years of extreme 4x4 action, product testing and the Off Road Nation at play. Baja racing to rock crawling, ATVs in the sand to motorcycles in the dirt, it's all here. Rate them, share them and upload your own.
ATV Reviews -
Honda, Suzuki, Yamaha, Polaris, Kawasaki, Can-Am. First rides to long-term tests, check out the latest in ATVs, UTVs and Side-by-Side vehicles of every make and model. Read expert opinions and follow custom project vehicles.
Axxxtion Sports.....
Axxxtion Sports is heating things up with their 2010 Winter Heat snowmobile calendar! Simply Sexy!
JC Whitney: Parts and Accessories for Jeep

Enewsletters

Stay on Top of All the Action:
Sign up for Off-Road.com's Enewsletters

Source: Jeep at Off-Road.com,
Click here